[1]刘晶峰,赵紫玉,方建成,等.过冷熔体枝晶生长的相场法数值模拟[J].华侨大学学报(自然科学版),2009,30(3):239-243.[doi:10.11830/ISSN.1000-5013.2009.03.0239]
　LIU Jing-feng,ZHAO Zi-yu,FANG Jian-cheng,et al.Numerical Simulation of Dendritic Growth into Undercooled Melt Using Phase-Field Method[J].Journal of Huaqiao University(Natural Science),2009,30(3):239-243.[doi:10.11830/ISSN.1000-5013.2009.03.0239]
点击复制

过冷熔体枝晶生长的相场法数值模拟()
分享到：

《华侨大学学报（自然科学版）》[ISSN:1000-5013/CN:35-1079/N]

卷:
第30卷
期数:
2009年第3期
页码:
239-243
栏目:
出版日期:
2009-05-20

文章信息/Info

Title:
Numerical Simulation of Dendritic Growth into Undercooled Melt Using Phase-Field Method
文章编号:
1000-5013(2009)03-0239-05
作者:
刘晶峰; 赵紫玉; 方建成; 江开勇
华侨大学机电及自动化学院
Author(s):
LIU Jing-feng;  ZHAO Zi-yu;  FANG Jian-cheng;  JIANG Kai-yong
College of Mechanical Engineering and Automation, Huaqiao University, Quanzhou 362021, China
关键词:
相场法;  过冷熔体;  枝晶生长;  数值模拟
Keywords:
phase-field method;  undercooled melt;  dendritic growth;  numerical simulation
分类号:
TG111.4
DOI:
10.11830/ISSN.1000-5013.2009.03.0239
文献标志码:
A
摘要:
利用相场法模拟纯物质过冷熔体中的枝晶生长过程,研究各向异性强度、过冷度、扰动等对枝晶生长的影响.结果表明,扰动会促发侧向分枝的形成,但不影响枝晶尖端的稳态生长行为; 随着各向异性强度的增大,枝晶尖端生长速度加快,枝晶结构特征愈加明显; 过冷度的增加,枝晶尖端稳定性遭到破坏,甚至出现分叉.讨论网格步长对模拟结果的影响,指出在兼顾精度与效率的同时应优先选取粗网格.
Abstract:
Based on a phase-field model,a series of numerical calculations of dendritic growth into undercooled melt for a pure material were performed,and the influence of some physical parameters,including anisotropy strength,undercooling and noise factor,on dendritic growth were investigated.Results showed that the noise could trigger the growth of side-branches,but this did not influence the selection of the tip operating state.The greater the anisotropy strength,the faster the tip velocity and the more obvious the characteristics of the dendritic structure.With the increase in undercooling,the stability of the tip operating state was gradually upset,and if seriously,branching-off of the dendrite tip could be seen.Finally,effect of mesh size on simulation result was discussed,and it was pointed out that the coarser mesh should be selected preferably when the resolution and time of computation is considered simultaneously.

参考文献/References:

[1] KOBAYASHI R. Modeling and numerical simulations of dendritic crystal [J]. Physical Review D, 1993, (10):410-423.
[2] WANG S I, SEKERKA R F, WHEELER A A. Thermodynamically consistent phase-field models for solidifi-cation [J]. Physical Review D, 1993.189-200.
[3] WHEELER A A, MURRAY B T, SCHAEFER R J. Computation of dendrites using a phase field moad [J]. Physi-ca(D), 1993, (10):243-262.
[4] WHEELER A A, BOETINGER W J, MCFADDEN G B. Phase-field model for isothermal phase transition in binary alloys [J]. Physical Rev(E), 1992, (10):7424-7439.
[5] WARREN J A, BOETINGER W J. Prediction of dendritic growth and microsegregation patterns in a binary alloy u-sing the phase-field method [J]. Aeta Metall Mater, 1995(2):689-703.
[6] CONTI M. Growth of a needle crystal from an undercooled alloy melt [J]. Plays Rev(E), 1997(3):3197-3202.
[7] TIADEN J. Phase-field simuhtion of the peritectic solidification of Fe-C [J]. Journal of Crystal Growth, 1999, (Part 2):1275-1280.doi:10.1016/S0022-0248(98)01009-4.
[8] BECKERMANN C, DIEPERS H J, STEUBBACG I. Modeling melt convection in phase-field simulation of so-lidification [J]. Journal of Computational Physics, 1999.468-496.
[9] BOETTINGER W J, WARREN J A. Simulation of the cell to plane front transition during directional solidification at high velocity [J]. Journal of Crystal Growth, 1999, (3/4):583-591.doi:10.1016/S0022-0248(98)01063-X.
[10] ZHAO D P, JING T, LIU B C. The effects of phase-field parameters on grain growth morphologies in the solidifi-cation [J]. MATERIALS TRANSACTIONS, 2003(3):367-371.doi:10.2320/matertrans.44.367.
[11] 刘晶峰, 李洪友, 方建成. 铸造CAE系统的网格剖分技术 [J]. 华侨大学学报(自然科学版), 2008(3):327-330.

相似文献/References:

[1]刘晶峰,赵紫玉,蹇崇军,等.枝晶生长的相场法数值模拟[J].华侨大学学报(自然科学版),2010,31(1):6.[doi:10.11830/ISSN.1000-5013.2010.01.0006]
　LIU Jing-feng,ZHAO Zi-yu,JIAN Chong-jun,et al.Numerical Simulation of Dendritic Growth Using Phase-Field Method[J].Journal of Huaqiao University(Natural Science),2010,31(3):6.[doi:10.11830/ISSN.1000-5013.2010.01.0006]

备注/Memo

备注/Memo:
福建省自然科学基金资助项目(2006J0166); 华侨大学科研启动基金资助项目(07BS202)
更新日期/Last Update: 2014-03-23